李培伦,田伟,卢德唐
LI Peilun,TIAN Wei,LU Detang

• 1:中国石化胜利油田勘探开发研究院
• 2:中国科学技术大学近代力学系

摘要(Abstract)：

水力压裂实践表明,压裂停泵水锤现象会导致压降曲线出现周期性波动,这使得停泵压降的分析变得困难。鉴于此,提出了基于数字滤波的压裂停泵压降分析新方法,即首先采用井筒垂直管流方程将地面压力折算到井底压力,然后采用FIR滤波处理停泵后的压降数据,消除停泵水锤等噪声干扰,从而获得真实反映地层渗流的压降数据。以某低渗透油田的1口水力压裂井为对象,利用新方法开展了停泵压降分析,结果表明诊断结果与其他反演手段的解释结果相近,这在一定程度上验证了该方法的可靠性。本次提出的新方法可用于开展考虑水锤效应的压裂停泵压降分析,对于高效水力压裂实践具有一定指导作用。
Hydraulic fracturing practice shows that the phenomenon of the water hammer in the process of the fracturing pump-off leads to the periodic fluctuation of the pressure decline curve. Thereby, it becomes difficult to analyze the pressure decline. In view of this point, an new analyzing method based on the digital filtering for the fracturing pump-off pressure decline was proposed: First, the ground pressure was converted to the bottom pressure by the vertical pipe flow equation of the wellbore;then FIR filtering was used to deal with the pressure decline data after stopping the pump so as to eliminate the noise interference such as the water hammer of the pump and obtain the pressure decline data that truly reflect the seepage of the formation. Taking one hydraulic fractured well in the low-permeability oilfield as an example, the pump-off pressure decline analysis was carried out with the help of the new method, the diagnostic results were similar to those of the other inverting methods,Which to some extent verify the reliability of the method proposed in this study.The proposed new method in this study can be applied to conduct the analysis of the pump-off pressure decline considering the effect of the water hammer, and furthermore it possesses a certain guidance to the high-efficiency practice of hydraulic fracturing.

关键词(KeyWords)： 水力压裂;停泵压降分析;数字滤波
hydraulic fracturing;pump-off pressure decline analysis;digital filtering

Abstract:

Keywords:

基金项目(Foundation): 国家科技重大专项“渤海湾盆地济阳坳陷致密油开发示范工程”(2017ZX05072)

作者(Author): 李培伦,田伟,卢德唐
LI Peilun,TIAN Wei,LU Detang

DOI: 10.19597/j.issn.1000-3754.201811059

参考文献(References)：

• [1]周延军,马新仿,王建.低渗透油藏矩形井网水力压裂适应性研究[J].科学技术与工程,2011,11(21):5008-5010.ZHOU Yanjun,MA Xinfang,WANG Jian.Adaptability research of rectangular pattern for hydraulic fracturing in low permeability reservoir[J].Science Technology and Engineering,2011,11(21):5008-5010.
• [2]夏玫沁.裂缝闭合规律及其渗流特征研究[D].西安:西安石油大学,2015.XIA Meiqin.Research of crack closure law and seepage mechanisms[D].Xi’an:Xi’an Shiyou University,2015.
• [3]米尔卡J,埃克诺米德斯.油藏增产措施[M].3版.张保平,译.北京:石油工业出版社,2002.ECONOMIDES M J.Reservoir stimulation in petroleum production[M].3rd ed.ZHANG Baoping,translated.Beijing:Petroleum Industry Press,2002.
• [4]温杰雄,田伟,毕全福,等.基于数字滤波的压裂停泵数据反演方法[J].中国科学技术大学学报,2018,48(5):392-399.WEN Jiexiong,TIAN Wei,BI Quanfu,et al.A new data inversion analysis method based on digital filtered pump-stop data of hydraulic fracturing[J].Journal of University of Science and Technology of China,2018,48(5):392-399.
• [5]NOLTE K G.Determination of fracture parameters from fracturing pressure decline[R].SPE 8341,1979.
• [6]CHOI S K,HUANG W S.Impact of water hammer in deep sea water injection wells[R].SPE 146300,2011.
• [7]PICK A E.Method and apparatus for preventing water hammer in high pressure steam injection water heaters:USA 3984504[P].1976-10-05.
• [8]SIMPSON A R.Large water hammer pressures due to column separation in sloping pipes[D].Michigan:University of Michigan,1986.
• [9]GEERTSMA J,DEKLERK F.A rapid method of predicting width and extent of hydraulically induced fractures[J].Journal of Petroleum Technology,1969,21(12):1571-1581.
• [10]HOWARD G,FAST C R.Optimum fluid characteristics for fracture extension[J].API Drilling & Production Practice,1957,24(1):261-270.
• [11]CASTILLO J L.Modified fracture pressure decline analysis including pressure dependent leakoff[R].SPE 16417,1987.
• [12]DESROCHES J,GROENENBOOM J,WEIJERS L.Physical and numerical modeling of hydraulic fracture closure[J].SPE Production & Facilities,1996,11(2):122-128.
• [13]NOLTE K G.Fracturing-pressure analysis for nonideal behavior[J].Journal of Petroleum Technology,1991,43(2):210-218.
• [14]MAYERHOFER M J,ECONOMIDES M J,NOLTE K G.An experimental and fundamental interpretation of fracturing filter-cake fluid loss[R].SPE 22873,1991.
• [15]NOLTE K G,MACK M G,LIE W L.A systematic method for applying fracturing pressure decline:Part I[R].SPE-25845-MS,1993.
• [16]杨远东,邓志光.停泵水锤计算及其防护措施[J].中国给水排水,2000,16(5):29-32.YANG Yuandong,DENG Zhiguang.Calculation of water hammer caused by pump-stop and related prevention measures[J].China Water & Waste Water,2000,16(5):29-32.
• [17]RADER C M.Discrete Fourier transforms when the number of data samples is prime[J].Proceedings of the IEEE,1968,56(6):1107-1108.
• [18]ALLEN J B.Short term spectral analysis,synthesis and modification by discrete Fourier transform[J].IEEE Transactions on Acoustics Speech and Signal Processing,1977,25(3):235-238.
• [19]李庚银,陈志业,宁宇.快速傅里叶变换的两种改进算法[J].电力系统自动化,1997,21(12):37-40.LI Gengyin,CHEN Zhiye,NING Yu.Two modified algorithms for fast Fourier transform[J].Automation of Electric Power Systems,1997,21(12):37-40.
• [20]陈劲松,刘艳伟.基于窗函数的FIR数字滤波器设计[J].制造业自动化,2012,34(17):104-105.CHEN Jinsong,LIU Yanwei.Based on the window function of the FIR digital filter design[J].Manufacturing Automation,2012,34(17):104-105.