余海棠,何亚斌,刘艳梅,张添锦
YU Haitang,HE Yabin,LIU Yanmei,ZHANG Tianjin

• 1:延长油田股份有限公司
• 2:延安大学石油工程与环境工程学院

摘要(Abstract)：

为了进一步提高超低渗透油藏水驱开发后的采收率，使用高温高压动态吞吐渗吸驱油实验装置对储层天然岩心开展了动态渗吸驱油实验，优选出了最佳的吞吐渗吸驱油参数，并将其成功地应用到矿场试验中。室内实验结果表明：当使用质量分数为0.5%的阴-非离子型表面活性剂YN-11溶液作为渗吸液时可以显著提高动态吞吐渗吸采收率，并且随着渗吸液注入量的不断增大，渗吸采收率逐渐增大，最佳注入量为0.4 PV；当驱替流速在0.05～0.10 mL/min时，渗吸采收率较高；随着岩心中裂缝开度的增大，渗吸采收率逐渐增大，矿场实践中应尽可能地增大裂缝开度；随着关井时间的延长，渗吸采收率逐渐增大，推荐最佳的关井时间为120 h；随着吞吐次数的增加，渗吸采收率增幅逐渐减小，最佳吞吐次数为3次。矿场试验结果表明，S区块内4口井采取动态吞吐渗吸驱油措施后，日产油量明显提升，平均含水率明显降低，增油效果显著。研究成果对超低渗透油藏的高效开发具有一定的指导意义。
In order to furtherly improve recovery after water flooding development of ultra-low permeability reservoir,dynamic imbibition displacement experiment is carried out on natural core from reservoir by using high-temperature and high-pressure dynamic huff-n-puff imbibition displacement experimental equipment to optimize huff-npuff imbibition displacement parameters with successful application in field test. Lab experiment shows that 0.5%anionic-nonionic surfactant YN-11 solution used as imbibition solution can significantly improve imbibition recovery of dynamic huff-n-puff,and imbibition recovery increases gradually with increase of imbibition injection volume,with optimal injection volume of 0.4 PV. Imbibition recovery is high when displacement flow rate is 0.05～0.10 mL/min. Imbibition recovery increases gradually with increase of fracture aperture in the core,and fracture aperture should be increased as much as possible in field practice. Imbibition recovery increases gradually with extension of shut in duration,with recommended optimal shut in duration of 120 h,and incremental imbibition recovery gradually decreases with increase of huff-n-puff times,with optimal 3 times of huff-n-puff. Field test shows that daily oil production of 4 wells in Block S is significantly increased after dynamic huff-n-puff imbibition displacement,with average water cut significantly reduced. The research has guiding significance for efficient development of ultralow permeability reservoir.

关键词(KeyWords)： 超低渗透油藏;动态渗吸;高温高压;吞吐驱油效果;影响因素
ultra-low permeability reservoir;dynamic imbibition;high-temperature and high-pressure;huff-n-puff displacement effect;influence factor

Abstract:

Keywords:

基金项目(Foundation): 陕西省延安市科技局科技稳增长项目“提高石油采收率关键技术研究及示范推广”（2017WZZ-01-02）

作者(Author): 余海棠,何亚斌,刘艳梅,张添锦
YU Haitang,HE Yabin,LIU Yanmei,ZHANG Tianjin

DOI: 10.19597/j.issn.1000-3754.202110030

参考文献(References)：

• [1]韩小琴，石立华，柳朝阳，等.延长油田超低渗透油藏水平井分段压裂开采参数优化研究及应用[J].钻采工艺，2018,41(6):61-64.HAN Xiaoqin, SHI Lihua, LIU Zhaoyang, et al. A study on staged fracturing parameter optimization for horizontal wells in ultra-low permeability reservoirs at Yanchang Oilfield[J].Drilling&Production Technology,2018,41(6):61-64.
• [2]胡利民，程时清，唐蕾，等.超低渗透油藏菱形反九点井网合理排距[J].大庆石油地质与开发，2018,37(2):62-68.HU Limin,CHENG Shiqing,TANG Lei,et al.Reasonable row spacing of the diamond inverted nine-spot well pattern in ultra-low permeability oil reservoirs[J].Petroleum Geology&Oilfield Development in Daqing,2018,37(2):62-68.
• [3]齐银，白晓虎，宋辉，等.超低渗透油藏水平井压裂优化及应用[J].断块油气田，2014,21(4):483-485,491.QI Yin,BAI Xiaohu,SONG Hui,et al.Fracturing optimization and application of horizontal wells in ultra-low permeability reservoir[J].Fault-Block Oil&Gas Field,2014,21(4):483-485,491.
• [4]王选涛，王海华，李秉路，等.超低渗透油藏N2吞吐提高采收率影响因素[J].西安石油大学学报（自然科学版），2020,35(6):60-64.WANG Xuantao,WANG Haihua,LI Binglu,et al.Factors of influencing enhanced oil recovery of N2huff-puff in ultra-low permeability oil reservoir[J]. Journal of Xi’an Shiyou University(Natural Science Edition),2020,35(6):60-64.
• [5]安杰，唐梅荣，曹宗熊，等.超低渗透低压油藏水平井转变开发方式试验[J].岩性油气藏，2019,31(5):134-140.AN Jie,TANG Meirong,CAO Zongxiong,et al.Transformation of development model of horizontal wells in ultra-low permeability and low-pressure reservoirs[J]. Lithologic Reservoirs, 2019,31(5):134-140.
• [6]王栋，展转盈，马彬.致密油储层注水吞吐动态渗吸特征及影响因素[J].西安石油大学学报（自然科学版），2021,36(2):50-56.WANG Dong, ZHAN Zhuanying, MA Bin. Dynamic imbibition characteristics and influencing factors of water injection huff-puff in tight oil reservoir[J]. Journal of Xi’an Shiyou University(Natural Science Edition),2021,36(2):50-56.
• [7]董大鹏，李斌会，苑盛旺，等.基于核磁共振测试的低渗亲水岩心静态渗吸特征[J].大庆石油地质与开发，2021,40(2):60-65.DONG Dapeng,LI Binhui,YUAN Shengwang,et al.Spontaneous imbibition characteristics of the low-permeability water-wet core based on the NMR test[J].Petroleum Geology&Oilfield Development in Daqing,2021,40(2):60-65.
• [8]吴忠宝，李莉，阎逸群.超低渗油藏体积压裂与渗吸采油开发新模式[J].断块油气田，2019,26(4):491-494.WU Zhongbao,LI Li,YAN Yiqun.New development pattern of network fracturing and imbibition oil recovery for super-low permeability oil reservoirs[J]. Fault-Block Oil&Gas Field, 2019,26(4):491-494.
• [9] ARONOFSKY J S,MASSE L,NATANSON S G.A model for the mechanism of oil recovery from the porous matrix due to water invasion in fractured reservoirs[J]. Transactions of the AIME,1958,213(1):17-19.
• [10]王付勇，杨坤.致密油藏孔喉分布特征对渗吸驱油规律的影响[J].岩性油气藏，2021,33(2):155-162.WANG Fuyong,YANG Kun. Influence of pore throat size distribution on oil displacement by spontaneous imbibition in tight oil reservoirs[J].Lithologic Reservoirs,2021,33(2):155-162.
• [11]王庆国，王婷婷，陈阳，等.大庆扶余油层静态渗吸采油效果及其影响因素[J].油田化学，2018,35(2):308-312.WANG Qingguo,WANG Tingting,CHEN Yang,et al.Effect of static imbibition recovery and its influencing factors in Fuyu Reservoir of Daqing Oilfield[J]. Oilfield Chemistry, 2018, 35(2):308-312.
• [12]刘俣含，赵志成，石善志，等.基于正交试验的致密油渗吸影响因素分析[J].石油钻采工艺，2020,42(2):189-194.LIU Yuhan,ZHAO Zhicheng,SHI Shanzhi,et al.Analyzing the factors influencing the imbibition of tight oil based on orthogonal experiment[J]. Oil Drilling&Production Technology, 2020,42(2):189-194.
• [13]张健，赵娟，杨光，等.低渗油藏自发渗吸驱油效率测定新方法[J].油田化学，2020,37(4):726-729.ZHANG Jian,ZHAO Juan,YANG Guang,et al.A new method for measuring the efficiency of spontaneous imbibition and displacement in low permeability reservoirs[J].Oilfield Chemistry,2020,37(4):726-729.
• [14]丁金岗，惠峰，游川川，等.低渗砂岩油藏渗吸诱发压裂液运移规律实验研究[J].钻采工艺，2021,44(1):74-76.DING Jingang,HUI Feng,YOU Chuanchuan,et al.Experimental investigation of fracturing-fluid migration caused by spontaneous imbibition in fractured low-permeability sands[J]. Drilling&Production Technology,2021,44(1):74-76.
• [15]王晨光.致密砂岩油藏不同边界条件下自发渗吸特征[J].西安石油大学学报（自然科学版），2021,36(3):58-65,70.WANG Chenguang. Spontaneous imbibition characteristics in tight sandstone reservoir under different boundary conditions[J].Journal of Xi’an Shiyou University(Natural Science Edition),2021,36(3):58-65,70.
• [16]朱维耀，赵成圆，马启鹏，等.烷基甜菜碱表面活性剂疏水基碳链长度对低渗岩心自发渗吸的影响[J].特种油气藏，2021,28(4):102-107.ZHU Weiyao, ZHAO Chengyuan, MA Qipeng, et al. Effect of hydrophobic carbon chain length of alkyl betaine surfactant on spontaneous imbibition of low-permeability core[J]. Special Oil&Gas Reservoirs,2021,28(4):102-107.
• [17]李斌会，付兰清，董大鹏，等.松辽盆地北部致密砂岩高温高压吞吐渗吸实验[J].特种油气藏，2018,25(1):140-145.LI Binhui, FU Lanqing, DONG Dapeng, et al. High temperature-pressure huff-puff imbibition experiment in the tight sandstone reservoir of northern Songliao Basin[J].Special Oil&Gas Reservoirs,2018,25(1):140-145.
• [18]王秀宇，巨明霜，杨文胜，等.致密油藏动态渗吸排驱规律与机理[J].油气地质与采收率，2019,26(3):92-98.WANG Xiuyu, JU Mingshuang, YANG Wensheng, et al. Dynamic imbibition principles and mechanism of tight oil reservoirs[J]. Petroleum Geology and Recovery Efficiency, 2019, 26(3):92-98.
• [19]刘俊杰.鄂尔多斯盆地致密砂岩储层高温高压动态渗吸实验[J].大庆石油地质与开发，2020,39(5):161-168.LIU Junjie.Dynamic imbibition experiment of the high temperature high pressure tight sandstone reservoirs in Ordos Basin[J].Petroleum Geology&Oilfield Development in Daqing, 2020, 39(5):161-168.
• [20]周万富，王鑫，卢祥国，等.致密油储层动态渗吸采油效果及其影响因素[J].大庆石油地质与开发，2017,36(3):148-155.ZHOU Wanfu,WANG Xin,LU Xiangguo,et al.Effects of the dynamic imbibition recovery and its influencing factors for the tight oil reservoirs[J]. Petroleum Geology&Oilfield Development in Daqing,2017,36(3):148-155.
• [21]胡亚斐，李军诗，胡水清，等.动态渗吸对超低渗透油藏开发的影响及应用[J].特种油气藏，2021,28(4):123-128.HU Yafei,LI Junshi,HU Shuiqing,et al.Influence and application of dynamic imbibition on the development of ultra-low permeability reservoirs[J].Special Oil&Gas Reservoirs, 2021, 28(4):123-128.
• [22]谷潇雨，王朝明，蒲春生，等.裂缝性致密油藏水驱动态渗吸特征实验研究：以鄂尔多斯盆地富县地区长8储层为例[J].西安石油大学学报（自然科学版），2018,33(3):37-43.GU Xiaoyu, WANG Chaoming, PU Chunsheng, et al. Experimental study on dynamic imbibition characteristics of fractured tight sandstone reservoir during water flooding:An example from Chang 8 Reservoir of Fuxian area in Ordos Basin[J].Journal of Xi’an Shiyou University(Natural Science Edition),2018,33(3):37-43.