陈德春,吕飞,姚亚,肖良飞,秦延才,杨康敏
CHEN Dechun,L Fei,YAO Ya,XIAO Liangfei,QIN Yancai,YANG Kangmin

• 1:中国石油大学石油工程学院
• 2:胜利油田河口采油厂
• 3:河南油田石油工程技术研究院

摘要(Abstract)：

为了解决示功图无法判别抽油机井地面设备工况、实时测量和维护成本高等问题,推导建立了基于电功图的皮带式抽油机井工况诊断新模型。根据能量守恒原理和皮带式抽油机悬点运动规律,建立抽油机井地面示功图计算电功图的数学模型。基于该模型,建立11种皮带式抽油机井典型工况下的电功图图版,并对电功图图版进行特征分析和特征值提取,建立基于特征值的电功图工况诊断模型。现场实例计算分析表明:计算得到的电功图与实测电功图基本一致,上冲程平台功率值、下冲程平台功率值和功率曲线的平均相对误差分别为6.32%、7.16%和5.81%;电功图诊断结果与根据示功图进行井下工况诊断结果的符合率为100%,且电功图能够准确地判别抽油机井地面设备的工况。研究结果能提高工况诊断结果的可靠度与诊断范围,为采油系统智能分析和优化决策提供技术支持。
In order to solve the problems such as the working status cannot be identified for the surface equipment including the pump-wells,high-cost measurement and maintenance etc.,a new diagnosing model was deduced and established for the working status of the belt-pump-unit wells on the basis of the dynamometer cards. With the help of the energy conservation law and the motion laws of the pumper suspension center,the mathematical model was built to calculate the electrical diagrams by the dynamometer cards,and moreover eleven kinds of the electrical diagrams under the typical working status of the pumpers were presented,characteristically analyzed and furthermore the characteristic values were extracted,finally the diagnosing model of the working status was established on the basis of the values. The calculation and analysis of the field case show that there are basically coincident betweenthe achieved electrical diagrams and actually measured ones,the average relative errors of the electrical power on the up and down-stroke plats,power curve are 6. 32%,7. 16% and 5. 81% respectively; the coincidence rate is100% between the diagnosed results from the electrical diagrams and those of the underground operating conditions from dynamometer cards,and moreover the former can more accurately judge the working status of the surface instrument i. e. the pump-unit wells. The study achievements can improve the diagnostic reliability,expand the diagnostic range and provide the technical support for the intelligent analysis and optimization decision of the oil production system.

关键词(KeyWords)： 电功图;工况诊断;电功图图版;特征值;功图转化;皮带式抽油机井
electrical diagram;working status diagnosis;electrical diagram atlas;characteristic value;diagram transfer;belt-pump-unit well

Abstract:

Keywords:

基金项目(Foundation): 中国石化胜利油田分公司项目“智能井群管控软件开发”(YT1508);; 中国石化科技部项目“提高采油系统效率与智能化监控技术”(P15121)

作者(Author): 陈德春,吕飞,姚亚,肖良飞,秦延才,杨康敏
CHEN Dechun,L Fei,YAO Ya,XIAO Liangfei,QIN Yancai,YANG Kangmin

DOI: 10.19597/j.issn.1000-3754.201610026

参考文献(References)：

• [1]张琪.采油工程原理与设计[M].东营:中国石油大学出版社,2006:157-169.
• [2]何岩峰,吴晓东,韩国庆,等.示功图频谱分析新方法[J].石油学报,2008,29(4):619-624.
• [3]徐芃,徐士进,尹宏伟.有杆抽油系统故障诊断的人工神经网络方法[J].石油学报,2006,27(2):107-110.
• [4]Gibbs S G.Utility of motor-speed measurements in pumping-well analysis and control[J].SPE Production Engineering,1987,2(3):199-208.
• [5]Gibbs S G.Predicting the behavior of sucker-rod pumping systems[J].Journal of Petroleum Technology,1963,15(7):769-778.
• [6]韩国庆,吴晓东,张庆生,等.示功图识别技术在有杆泵工况诊断中的应用[J].石油钻采工艺,2003,25(5):70-74.
• [7]孙东.抽油机电参数远程智能故障诊断技术研究[J].自动化仪表,2012,33(5):22-24.
• [8]刘岢鑫.电参数反演抽油机井示功图技术研究[D].大庆:东北石油大学,2012.
• [9]贾德利,刘合,裴晓含,等.游梁式抽油机井井下泵功图测试方法[J].石油勘探与开发,2015,42(1):111-116.
• [10]谢雄.抽油机井系统动态实时分析[D].青岛:中国石油大学,2009.
• [11]石正宝.基于悬点实测示功图的抽油机井动态仿真研究[D].秦皇岛:燕山大学,2010.
• [12]戴颖龙.基于示功图分析的有杆泵抽油井故障诊断方法研究[D].沈阳:东北大学,2012.
• [13]陈培毅,姚春东,董世民,等.基于抽油机实测电功率的悬点示功图仿真模型[J].石油机械,2013,41(11):91-95.
• [14]张刚.电流法间接示功图测量方法研究[D].大庆:大庆石油学院,2009.
• [15]孙振华.游梁式抽油机采油系统实时评价方法研究[D].青岛:中国石油大学,2011.
• [16]陈德春,陈逸芸,孟红霞,等.助力深抽有杆泵井工况诊断模型[J].特种油气藏,2015,22(4):144-147.
• [17]王晓菡.用于工况诊断的示功图特征提取方法研究[D].青岛:中国石油大学,2011.
• [18]李虎君,张继芬,支连友.利用抽油机井实测功率曲线预测示功图[J].大庆石油地质与开发,1991,10(4):63-67.
• [19]陈培毅.基于抽油机实测电功率的悬点示功图仿真与工况诊断[D].秦皇岛:燕山大学,2013.
• [20]张世荣,李昌禧.游梁式抽油机示功图的间接测量[J].华中科技大学学报(自然科学版),2004,32(11):62-64.