任岚,胡哲瑜,赵金洲,林然,胡东风,李真祥,吴建军,彭思瑞
REN Lan,HU Zheyu,ZHAO Jinzhou,LIN Ran,HU Dongfeng,LI Zhenxiang,WU Jianjun,PENG Sirui

• 1:西南石油大学石油与天然气工程学院
• 2:油气藏地质及开发工程国家重点实验室
• 3:中国石化勘探分公司
• 4:中石油煤层气有限责任公司

摘要(Abstract)：

深层页岩气储层埋藏深、温度高、地层应力大、岩石塑性强，导致压裂缝网复杂度低，缝网导流能力不足，极大影响了深层页岩气储层的压裂效果。评价深层页岩气压裂缝网的有效性，可以指导深层页岩气储层通过高效地压裂改造获得稳定高产的页岩气产能，具有重要的商业价值。基于川东南丁山地区深层页岩地质条件与裂缝导流能力实验，开展了深层页岩高闭合应力条件下裂缝导流有效性评价。结果表明：随着闭合应力的增大，自支撑裂缝与支撑裂缝导流能力呈快速递减的趋势，当闭合应力达到55 MPa时，自支撑裂缝的导流能力仅为0.1μm~2·cm，反映了深层条件下剪切裂缝难以满足流体流动的现状；在铺砂条件下，当闭合应力大于69 MPa时，粒径为40/70目的陶粒可有效满足主裂缝的导流要求，粒径为70/120目的陶粒与石英砂均可达到分支裂缝的导流要求；同时定量计算了满足主裂缝与分支裂缝导流要求的最低铺砂浓度，并绘制了不同类型、粒径的支撑剂用量设计图版。研究成果为深层页岩气储层压裂的支撑剂选择与优化提供了技术参考。
Deep shale gas reservoirs with deep burial, high temperature, high stratigraphic stress and high rock ductility lead to low complexity of fracture network and insufficient fracture network conductivity, causing much impact on effect of deep shale gas reservoir fracturing stimulation. Evaluating effectiveness of deep shale gas reservoir fracture network can conduct efficient fracturing stimulation for high and stable shale gas production, with high commercial value. Based on experiment with geological circumstances and fracture conductivity of deep shale in Dingshan area of southeast Sichuan, fracture conductivity effectiveness in high closure stress regime in deep shale is evaluated. The experiment results show that as closure stress increases, self-propped fracture and propped fracture conductivity rapidly decrease, and self-propped fracture conductivity is only 0.1 μm~2·cm when closure stress achieves 55 MPa, reflecting difficulties of shear fracture in satisfying fluid flow in deep formation. When closure stress is higher than 69 MPa in sand-laying situation, ceramsite with partical size of 40/70 mesh can effectively satisfy the conductivity requirements of main fracture, and both ceramsite with partical size of 70/120 mesh and quartz sand can satisfy the conductivity requirements of branch fractures. Meanwhile, minimum sanding concentration to satisfy the requirements of main fracture and branch fractures conductivity is quantitatively calculated, and proppant dosage design charts for various kinds and grain sizes are plotted. The study provides technical guide for proppants selection and optimization for deep shale gas reservoirs fracturing.

关键词(KeyWords)： 深层页岩气;复杂缝网;裂缝有效性;铺砂浓度;导流能力
deep shale gas;complex fracture network;fracture effectiveness;sanding concentration;conductivity

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目“深层超深层页岩气水平井压裂缝网高效建造理论与方法研究”（U21B2071）;国家自然科学基金项目“基于DEM-LBM流固耦合的深层页岩气水力裂缝长效支撑理论与方法研究”（52104039）;; 中国石油-西南石油大学创新联合体科技合作项目“多层叠置页岩储层地质力学参数场预测及缝网创建理论与优化技术”（2020CX030201）

作者(Author): 任岚,胡哲瑜,赵金洲,林然,胡东风,李真祥,吴建军,彭思瑞
REN Lan,HU Zheyu,ZHAO Jinzhou,LIN Ran,HU Dongfeng,LI Zhenxiang,WU Jianjun,PENG Sirui

DOI: 10.19597/j.issn.1000-3754.202203064

参考文献(References)：

• [1]赵金洲，任岚，蒋廷学，等.中国页岩气压裂十年：回顾与展望[J].天然气工业，2021,41(8):121-142.ZHAO Jinzhou,REN Lan,JIANG Tingxue,et al.Ten years of gas shale fracturing in China:Review and prospect[J].Natural Gas Industry,2021,41(8):121-142.
• [2] SHABRO V,TORRES-VERDIN C,JAVADPOUR F.Numerical simulation of shale-gas production:From pore-scale modeling of slip-flow,Knudsen diffusion,and Langmuir desorption to reservoir modeling of compressible fluid[R].SPE 144355,2011.
• [3]蒋廷学.页岩油气水平井压裂裂缝复杂性指数研究及应用展望[J].石油钻探技术，2013,41(2):7-12.JIANG Tingxue.The Fracture complexity index of horizontal wells in shale oil and gas reservoirs[J]. Petroleum Drilling Techniques,2013,41(2):7-12.
• [4] GUO C H,WEI M Z,CHEN H W,et al.Improved numerical simulation for shale gas reservoirs[R].OTC 24913,2014.
• [5] SUN H, CHAWATHéA, HOTEIT H, et al. Understanding shale gas flow behavior using numerical simulation[J]. SPE Journal,2015,20(1):142-154.
• [6]李庆辉，李少轩，刘伟洲.深层页岩气储层岩石力学特性及对压裂改造的影响[J].特种油气藏，2021, 28(3):130-138.LI Qinghui,LI Shaoxuan,LIU Weizhou. Rock mechanical properties of deep shale gas reservoirs and their influence on fracturing stimulation[J]. Special Oil&Gas Reservoirs,2021,28(3):130-138.
• [7]陈星宇，何昀宾，何封，等.非连续铺砂裂缝动态闭合实验[J].断块油气田，2018,25(3):398-403.CHEN Xingyu, HE Junbin, HE Feng, et al. Experiment of dynamic closure behavior of discontinuous sanding fracture[J].Fault-Block Oil&Gas Field,2018,25(3):398-403.
• [8] ROODHART L P, KULPER T O H, DAVIES D R. Proppantpack and formation impairment during gas-well hydraulic fracturing[J].SPE Production Engineering,1988,3(4):438-444.
• [9]王海涛，仲冠宇，卫然，等.降低深层页岩气井压裂施工压力技术探讨[J].断块油气田，2021,28(2):162-167.WANG Haitao,ZHONG Guanyu,WEI Ran, et al. Discussion on technology of reducing fracturing operation pressure in deep shale gas well[J]. Fault-Block Oil&Gas Field, 2021, 28(2):162-167.
• [10]王兴文，何颂根，林立世，等.威荣区块深层页岩气井体积压裂技术[J].断块油气田，2021,28(6):745-749.WANG Xingwen,HE Songgen,LIN lishi,et al. Volume fracturing technology of deep shale gas well in Weirong block[J].Fault-Block Oil&Gas Field,2021,28(6):745-749.
• [11]熊俊雅，杨兆中，杨磊，等.压裂填砂裂缝导流能力室内研究进展与展望[J].特种油气藏，2020,27(3):1-7.XIONG Junya,YANG Zhaozhong,YANG Lei,et al.Laboratory progress and prospect of sand-packed fracture conductivity in fracturing[J].Specail Oil&Gas Reservoirs,2020,27(3):1-7.
• [12]谢斌，任岚，贾久波，等.火山岩体积压裂的自支撑裂缝导流能力实验评价[J].大庆石油地质与开发，2020,39(6):77-84.XIE Bin,REN Lan,JIA Jiubo,et al.Experimental evaluation of the self-supporting fracture conductivity for the volume fracturing in volcanic rocks[J]. Petroleum Geology&Oilfield Development in Daqing,2020,39(6):77-84.
• [13]甄怀宾，赵海峰，王成旺，等.砂砾岩人造裂缝导流能力物理模拟[J].新疆石油地质，2021,42(1):81-87.ZHEN Huaibin, ZHAO Haifeng, WANG Chengwang, et al.Physical modelling of artificial fracture conductivity of glutenite[J]. Xinjiang Petroleum Geology,2021,42(1):81-87.
• [14] PEDLOW J,SHARMA M. Changes in shale fracture conductivity due to interactions with water-based fluids[R]. SPE 168586,2014.
• [15]张阳，任晓娟，李展峰，等.支撑裂缝导流能力影响因素实验分析[J].油气藏评价与开发，2014,4(5):24-27.ZHANG Yang,REN Xiaojuan,LI Zhanfeng,et al.Experimental analysis of influential factors of propped fracture conductivity[J]. Reservoir Evaluation and Development, 2014, 4(5):24-27.
• [16]刘学伟.页岩储层水力压裂支撑裂缝导流能力影响因素[J].断块油气田，2020,27(3):394-398.LIU Xuewei.Influencing factors of hydraulic propped fracture conductivity in shale reservoir[J]. Fault-Block Oil&Gas Field,2020,27(3):394-398.
• [17]车飞翔，樊婷婷，薛波，等.石英砂陶粒组合支撑剂导流能力影响因素[J].断块油气田，2022,29(1):134-138.CHE Feixiang,FAN Tingting,XUE Bo,et al.Influencing factors of flow conductivity of combined quartz sand-ceramsite proppant[J]. Fault-Block Oil&Gas Field, 2022, 29(1):134-138.
• [18]苏映宏，吴忠维，崔传智，等.水力压裂支撑裂缝导流能力计算与分析[J].大庆石油地质与开发，2021,40(6):62-71.SU Yinghong,WU Zhongwei,CUI Chuanzhi,et al. Calculation and analysis of the propped fracture conductivity created by hydraulic fracturing[J]. Petroleum Geology&Oilfield Development in Daqing,2021,40(6):62-71.
• [19]郭天魁，张士诚.影响支撑剂嵌入的因素研究[J].断块油气田，2011,18(4):527-529.GUO Tiankui, ZHANG Shicheng. Study on the factors affecting proppant embedment[J].Fault-Block Oil&Gas Field,2011,18(4):527-529.
• [20]温庆志，张士诚，王雷，等.支撑剂嵌入对裂缝长期导流能力的影响研究[J].天然气工业，2005,25(5):65-68.WEN Qingzhi,ZHANG Shicheng,WANG Lei,et al.Influence of proppant embedment on fracture long term flow conductivity[J].Natural Gas Industry,2005,25(5):65-68.
• [21] ALRAMAHI B,SUNDBERG M I.Proppant embedment and conductivity of hydraulic fractures in shales[R]. ARMA 12-291,2012.
• [22]梁天成，才博，蒙传幼，等.水力压裂支撑剂性能对导流能力的影响[J].断块油气田，2021,28(3):403-407.LIANG Tiancheng,CAI Bo,MENG Chuanyou,et al. The effect of proppant performance of hydraulic fracturing on conductivity[J].Fault-Block Oil&Gas Field,2021,28(3):403-407.
• [23] FREDD C N,Mcconnell S B,Boney C L,et al.Experimental study of fracture conductivity for water-fracturing and conventional fracturing applications[J].SPE Journal,2001,6(3):288-298.
• [24]张潦源，曲占庆，吕明锟，等.不同支撑剂组合对复杂裂缝支撑效果的影响[J].断块油气田，2021,28(2):278-283.ZHANG Liaoyuan,QU Zhanqing,LüMingkun,et al. Support effect of different particle proppant combinations on complex fractures[J]. Fault-Block Oil&Gas Field, 2021, 28(2):278-283.
• [25]张峰.高温高压条件下支撑剂导流能力评价研究[J].化工管理，2019,7(19):80-81.ZHANG Feng. Evaluation of proppant conductivity under high temperature and high pressure[J].Chemical Enterprise Management,2019,7(19):80-81.
• [26]杨雪，袁旭，何小东，等.酸液溶蚀作用对支撑剂性能的影响[J].断块油气田，2021,28(1):68-71.YANG Xue,YUAN Xu,HE Xiaodong,et al. The effect of acid corrosion on proppant properties[J]. Fault-Block Oil&Gas Field,2021,28(1):68-71.
• [27] JANSEN T, ZHU D, HILL A D.The effect of rock mechanical properties on fracture conductivity for shale formations[R].SPE173347,2015.
• [28]陈勉，金衍.基于岩心分析的页岩气压裂工艺参数优选[J].石油钻探技术，2012,40(4):7-12.CHEN Mian,JIN Yan.Shale gas fracturing technology parameters optimization based on core analysis[J].Petroleum Drilling Techniques,2012,40(4):7-12.
• [29]王桂庆.页岩储层吸水特征及其对裂缝导流能力的影响[J].断块油气田，2020,27(1):95-98.WANG Guiqing.Water absorption characteristics of shale reservoir and its effect on fracture conductivity[J].Fault-Block Oil&Gas Field,2020,27(1):95-98.
• [30] ZHANG J,KAMENOV A,ZHU D,et al.Laboratory measurement of hydraulic fracture conductivities in the Barnett shale[R].SPE 163839,2013.
• [31]李士斌，陈波涛，张海军，等.清水压裂自支撑裂缝面闭合残留宽度数值模拟[J].石油学报，2010,31(4):680-683.LI Shibin,CHEN Botao,ZHANG Haijun,et al.Numerical simulation on residual width of fractures in wells with clear water fracturing without proppant[J]. Acta Petrolei Sinica, 2010, 31(4):680-683.
• [32]邹雨时，张士诚，马新仿.四川须家河组页岩剪切裂缝导流能力研究[J].西安石油大学学报（自然科学版），2013,28(4):69-72,77.ZOU Yushi,ZHANG Shicheng,MA Xinfang.Experimental study on flow guiding capacity of shear fracture in the shale of Xujiahe Formation in Sichuan[J]. Journal of Xi’an Shiyou University(Natural Science Edition),2013,28(4):69-72,77.
• [33]高长龙.煤岩复杂裂缝导流能力评价研究[D].大庆：东北石油大学，2016.GAO Changlong.Evaluation study on flow conductivity of complex fractures of coal bed[D].Daqing:Northeast Petroleum University,2016.
• [34]焦红岩.长裂缝导流能力衰减预测模型研究与应用[D].青岛：中国石油大学（华东），2017.JIAO Hongyan. Research and application of decline prediction model for long-fracture conductivity[D].Qingdao:China University of Petroleum(East China),2017.
• [35] LIN R,LI G M,ZHAO J Z,et al.Productivity model of shale gas fractured horizontal well considering complex fracture morphology[J].Journal of Petroleum Science and Engineering,2022,208:109511.