王德民,张怀钰,王研,朱焱,崔建峰,何志国,张蕾蕾,刘金堂,张雨
WANG Demin,ZHANG Huaiyu,WANG Yan,ZHU Yan,CUI Jianfeng,HE Zhiguo,ZHANG Leilei,LIU Jintang,ZHANG Yu

• 1:中国石油大庆油田有限责任公司
• 2:中国石油大庆油田有限责任公司采油工程研究院
• 3:中国石油大庆油田有限责任公司第二采油厂
• 4:中国石油大庆油田有限责任公司第一采油厂

摘要(Abstract)：

目前高含水老油田的年产油量在中国年产油量的占比在70%以上，要保持稳产就必须要保证高含水老油田产量稳定的开发需求，为了满足这一现场需求，通过完善回注层段分层注水技术、不动管柱实施增注工艺以及同井注采采出层及回注层参数录取方法，大庆油田提出了一种结合高效井下油水分离、桥式封隔器等工艺的有杆泵同井注采技术。结果表明：同井注采技术在不打新井的情况下可有效增加油水井对应连通方向、增加注水层点和提高波及体积；同时能够将同一区块分采的2套或多套层系构建起一套立体高效开发层系，使大部分水不举升到地面而直接在地层内部循环驱替。现场试验表明，试验区平均单井产液量降低了94.5%，综合含水率下降了34.1%；地下回注注水单耗降低了83.0%；井下管柱平均工作寿命可增加到1.5 a以上。研究成果能够有效提高油井产量、降低开采成本、提高采收率，实现了超过目前“极限含水”条件下继续经济、有效的开采，对老油田长期持续稳产具有重要意义。
At present, the proportion of annual oil production of high water-cut mature oilfields in Chinese annual oil production is greater than 70%. Keeping stable production must be ensured by stable output development requirement of high water-cut mature oilfields. In order to meet this field requirement, by meas of perfecting separatelayer water injection of reinjection interval, fixed string injection increasing, and parameters recording of singlewell production interval and reinjection interval, a single-well rod-pump injection-production technique is proposed in Daqing oilfield, combined with techniques of high-efficient downhole oil-water separation and bridge packer. The results show that single-well injection and production technology without drilling new wells can efficiently increase corresponding connective direction of injectors and producers, increase water-injection layer points and increase swept volume. Meanwhile, 2 or more sets of strata series produced separately in the same block can be constructed as a set of 3D high-efficient development strata series, making most of the water circulate and displace inside the formation without lifting to the surface. Field test shows average single well fluid production decreased by 94.5%and water cut decreased by 34.1% and in test area. Unit energy consumption of subsurface reinjection is decreased by 83.0% and average operation life of downhole pipe string is extended to more than 1.5 years. The research achievement can efficiently increase oil production with production cost reduced and recovery enhanced, realizing continuously economic and effective production in current “ultimate water cut” condition and providing significance for long-term sustainable and stable production of mature oilfields.

关键词(KeyWords)： 同井注采;井下油水分离;有杆泵;节能降耗
single-well injection and production;downhole oil-water separation;rod pump;energy saving and consumption reduction

Abstract:

Keywords:

基金项目(Foundation): 中国石油天然气股份有限公司重大工程技术现场试验项目“井下油水分离同井注采技术现场试验”（2015F-0201）

作者(Author): 王德民,张怀钰,王研,朱焱,崔建峰,何志国,张蕾蕾,刘金堂,张雨
WANG Demin,ZHANG Huaiyu,WANG Yan,ZHU Yan,CUI Jianfeng,HE Zhiguo,ZHANG Leilei,LIU Jintang,ZHANG Yu

DOI: 10.19597/j.issn.1000-3754.202206011

参考文献(References)：

• [1]王德民.强化采油方面的一些新进展[J].大庆石油学院学报，2010,34(5):19-26.WANG Demin. New developments in improved oil recovery[J].Journal of Daqing Petroleum Institute,2010,34(5):19-26.
• [2]王德民，王研，张蕾蕾，等．同井注采配套工艺技术及应用效果[J]．中国石油大学学报（自然科学版），2023,47(2):64-72.WANG Demin,WANG Yan,ZHANG Leilei,et al.Matching technology and application effect of injection-production in the same well[J].Journal of China University of Petroleum(Edition of Natural Science),2023,47(2):64-72.
• [3]王锐，伦增珉，吕成远，等.中外提高采收率新技术研究现状及发展趋势[J].油气地质与采收率，2021,28(5):81-86.WANG Rui, LUN Zengmin, LüChengyuan, et al. Research status and development trends of worldwide new technologies for enhanced oil recovery[J]. Petroleum Geology and Recovery Efficiency,2021,28(5):81-86.
• [4]王德民.技术创新大幅度增加大庆油田可采储量确保油田长期高产[J].大庆石油地质与开发，2019,38(5):8-16.WANG Demin.Technical innovation greatly increase the recoverable reserve and ensure long-term high production of Daqing Oilfield[J].Petroleum Geology&Oilfield Development in Daqing,2019,38(5):8-16.
• [5]王德民，王研，刘金堂，等．同井注采井下油水分离器的研制及分离效果[J]．中国石油大学学报（自然科学版），2022,46(5):66-72.WANG Demin,WANG Yan,LIU Jintang,et al. Development and separation effect of downhole oil/water separator in single-well injection and production[J]. Journal of China University of Petroleum(Edition of Natural Science), 2022, 46(5):66-72.
• [6]杨树人，谢威.同井注采油水分离器的优化设计[J].特种油气藏，2011,18(6):106-108.YANG Shuren,XIE Wei. Optimization design of oil-water separator for injection-production in the same well[J]. Special Oil&Gas Reservoirs,2011,18(6):106-108.
• [7]杨树人，汪岩，王春生，等.多杯等流型气锚的水力设计[J]．大庆石油学院学报，2006,30(3):34-36.YANG Shuren,WANG Yan,WANG Chunsheng,et al. Hydraulic design for liquid-gas separator with multi-cups and isoflowrate[J].Journal of Daqing Petroleum Institute,2006,30(3):34-36.
• [8]王研，苗新蕾，崔海清，等.多杯等流型气锚的脱气效率分析[J].大庆石油学院学报，2007,31(4):32-36.WANG Yan,MIAO Xinlei,CUI Haiqing,et al.Analysis of degassing efficiency for multicup isoflux gas anchor[J].Journal of Daqing Petroleum Institute,2007,31(4):32-36.
• [9]刘保君，秦梓钧，李勇生，等.多杯等流分离器气液两相流动中气泡群流动研究[J].当代化工，2016, 45(6):1163-1166,1169.LIU Baojun, QIN Zijun, LI Yongsheng, et al. Bubble swarm flow in gas-liquid two-phase flow in a multicup isoflux separator[J]. Contemporary Chemical Industry, 2016, 45(6):1163-1166,1169.
• [10]张赫，单高军，杜庆龙，等.大庆长垣油田特高含水后期水驱开发技术难题及其对策[J].大庆石油地质与开发，2022,41(4):60-66.ZHANG He, SHAN Gaojun, DU Qinglong, et al. Technical challenges and solutions of water flooding development in late stage of ultra-high water cut in Placanticline oilfield in Daqing[J]. Petroleum Geology&Oilfield Development in Daqing,2022,41(4):60-66.
• [11]侯雨辰，朱焱，潘登，等.聚合物驱流动压力对驱油效果的影响[J].大庆石油地质与开发，2021,40(3):109-119.HOU Yuchen, ZHU Yan, PAN Deng, et al. Effect of flowing pressure on the oil displacement efficiency during polymer flooding[J]. Petroleum Geology&Oilfield Development in Daqing,2021,40(3):109-119.
• [12]赵秀娟，吴家文，左松林，等.大庆油田井网加密调整效果及其发展趋势[J].油气地质与采收率，2022, 29(5):141-145.ZHAO Xiujuan, WU Jiawen, ZUO Songlin, et al. Effect and trend of well pattern infillings in Daqing Oilfield[J]. Petroleum Geology and Recovery Efficiency,2022,29(5):141-145.
• [13]李贺.大庆长垣油田特高含水后期水驱控水提效试验区开发效果[J].大庆石油地质与开发，2021,40(4):94-100.LI He. Evaluation on development effects of water cut control and efficiency-improvement test areas at the late stage of ultra-high water cut in Daqing Placanticline Oilfield[J]. Petroleum Geology&Oilfield Development in Daqing,2021,40(4):94-100.
• [14]王建忠，宋宪坤，付颖超，等.水驱砂岩油藏在不同水质下的渗透率时变特征[J].石油与天然气地质，2021,42(5):1234-1242.WANG Jianzhong,SONG Xiankun,FU Yingchao,et al. Timevarying permeability of sandstone reservoirs under waterflooding of different water quality[J].Oil&Gas Geology,2021,42(5):1234-1242.
• [15]刘丽杰，张先敏，魏祥祥，等.特高含水期剩余油分类评价方法[J].油气地质与采收率，2022,29(5):83-90.LIU Lijie,ZHANG Xianmin,WEI Xiangxiang,et al.Development and separation effect of downhole oil/water separator in single-well injection and production[J]. Petroleum Geology and Recovery Efficiency,2022,29(5):83-90.
• [16]张世明，杨勇.特高含水水驱油藏流场边界动态追踪模型研究[J].油气地质与采收率，2021,28(2):91-99.ZHANG Shiming, YANG Yong. Study on the dynamic tracking model of flow field boundaries in water drive reservoirs at ultrahigh water cut stage[J]. Petroleum Geology and Recovery Efficiency,2021,28(2):91-99.
• [17]刘北，李丽雄，李树德，等.田东油田超长稳产与高效益开发做法与效果[J].大庆石油地质与开发，2021,40(3):94-102.LIU Bei,LI Lixiong,LI Shude,et al. Stimulations and effects of super-long stable production and high-benefit development in Tiandong Oilfield[J]. Petroleum Geology&Oilfield Development in Daqing,2021,40(3):94-102.
• [18]张继成，卢光夫，匡力，等.同井注采井本井提高采收率潜力研究[J].数学的实践与认识，2018,48(23):69-74.ZHANG Jicheng,LU Guangfu,KUANG Li,et al. Study on improving recovery efficiency of well injection and production well in the same well[J].Mathematics in Practice and Theory,2018,48(23):69-74.
• [19]张继成，匡力，郑灵芸，等.一种计算同井注采泵合理排量的方法[J]．西安石油大学学报（自然科学版），2017,32(5):49-54.ZHANG Jicheng,KUANG Li,ZHENG Lingyun,et al.A method to calculate reasonable flow-rate of injection and production pumps for the same well[J].Journal of Xi’an Shiyou University(Natural Science Edition),2017,32(5):49-54.
• [20]董康兴，张怀钰，程天才，等.同井注采系统抽油泵泵效计算方法及影响因素分析[J].数学的实践与认识，2019,49(17):165-170.DONG Kangxing,ZHANG Huaiyu,CHENG Tiancai,et al.Calculation method of pumping efficiency in the injection-production system of the same well and analysis of influencing factors[J].Mathematics in Practice and Theory,2019,49(17):165-170.
• [21]程天才，姜民政，董康兴，等.有杆泵同井注采系统杆柱动力学分析[J].地震工程与工程振动，2019,39(6):97-105.CHENG Tiancai, JIANG Minzhen, DONG Kangxing, et al.Dynamic analysis of rod and column of the single-well injectionproduction system with sucker-rod pump[J]. Earthquake Engineering and Engineering Dynamics,2019,39(6):97-105.
• [22]姜民政，张迪，段天玉，等.有杆泵同井注采系统工况诊断方法研究[J].石油机械，2018,46(1):78-82.JIANG Minzheng,ZHANG Di,DUAN Tianyu,et al.Research on fault diagnosis method for the sucker rod pump injection-production system[J]. China Petroleum Machinery, 2018, 46(1):78-82.