卞晓冰,蒋廷学,卫然,苏瑗,贾长贵,李双明
BIAN Xiaobing,JIANG Tingxue,WEI Ran,SU Yuan,JIA Changgui,LI Shuangming

• 1:中国石油化工股份有限公司石油工程技术研究院
• 2:页岩油气富集规律与有效开发国家重点实验室

摘要(Abstract)：

为了精细描述页岩气水平井较长的排采周期,基于商业模拟器Eclipse的双孔双渗模型,将压裂过程等效为注水过程,并进行地层压力场及饱和度场的初始化,以消除常规压裂井数值模拟忽略压裂施工对排采影响的局限性。基于渝东南某常压页岩气数据,建立了多段压裂水平井压后排采模型,并优化了排采参数。结果表明:压后立即采取返排措施,排采压差为12 MPa以上,初期日排液量不小于50 m3,压裂液同步彻底破胶,常压页岩气水平井排采效果较好。以此为基础,指导该区2口水平井的压后排采,取得了较好的效果。
In order to finely characterize the long-period flowback and production of the horizontal well in a shale gas reservoir,on the basis of the dual-porosity and dual-permeability model of the commercial simulator Eclipse,the fracturing process was equivalent to one of the water injection,the initializations were conducted for the formation pressure and saturation fields so as to eliminate the limitations of ignoring the influences of the fracturing operation on the flowback and production for the numerical simulation of the conventional fractured wells. Based on the data of the normal-pressure shale gas reservoir in Southeast Chongqing,the model of multi-fractured horizontal well was established for the post-frac flowback and production,and moreover the corresponding parameters were optimized. The results show that the rapid flowback after the fracturing,the differential pressure is be above 12 MPa,and the initial daily liquid production is no less than 50 m3,the fracturing fluid is broken synchronously and completely,thus much better operation effects can be achieved for the normal-pressureshale-gas horizontal wells. Onthe parameters stated above,two-horizontal-well post-frac flowback and production were guided and furthermore pretty better effects were obtained in the end.

关键词(KeyWords)： 常压页岩气;水平井;返排;数值模拟;参数优化
normal-pressure shale gas;horizontal well;flowback;numerical simulation;parameter optimization

Abstract:

Keywords:

基金项目(Foundation): 国家重大科技专项(2016ZX05061-002);; 国家自然科学基金(51490653);; 中国石化科技攻关项目(P14091)

作者(Author): 卞晓冰,蒋廷学,卫然,苏瑗,贾长贵,李双明
BIAN Xiaobing,JIANG Tingxue,WEI Ran,SU Yuan,JIA Changgui,LI Shuangming

参考文献(References)：

• [1]唐颖,张金川,张琴,等.页岩气井水力压裂技术及其应用分析[J].天然气工业,2010,30(10):33-38.
• [2]FAN L,THOMPSON J W,ROBINSON J R.Understanding gas production mechanism and effectiveness of well stimulation in Haynesville Shale through reservoir simulation[R].SPE 136696,2010.
• [3]XIAO Y T,BISCG R V,LIU F,et al.Evaluation in data rich Fayetteville shale gas plays-integrating physics based reservoir simulations with data driven approaches for uncertainty reduction[R].IPTC 14940,2011.
• [4]GULEN G,IKONNIKOVA S,BROWNING J,et al.Fayetteville shale-production outlook[J].SPE Economics&Management,2014:1-13.
• [5]房大志.页岩气藏开发的关键因素[J].科技导报,2013,31(31):70-74.
• [6]周德华,焦方正,贾长贵,等.JY1HF页岩气水平井大型分段压裂技术[J].石油钻探技术,2014,42(1):75-80.
• [7]李关访,张浩,于洋,等.非常规压裂技术在川东页岩气开发中的应用[J].钻采工艺,2014,37(1):57-60.
• [8]CLARKSON C R.Modeling 2-phase flowback of multi-fractured horizontal wells completed in shale[R].SPE 162593,2012.
• [9]叶登胜,李建忠,朱炬辉,等.四川盆地页岩气水平井压裂实践与展望[J].钻采工艺,2014,37(3):42-44.
• [10]肖博,张士诚,雷鑫,等.页岩气藏清水压裂减阻剂优选与性能评价[J].油气地质与采收率,2014,21(2):102-105.
• [11]卞晓冰,蒋廷学,苏瑗,等.裂缝参数对压裂后页岩气水平井排采影响[J].特种油气藏,2014,21(4):126-129.
• [12]郭小哲,赵刚.页岩气藏压裂缝网模拟及沟通效果评价[J].特种油气藏,2015,22(1):99-102.
• [13]王松,杨洪志,赵金洲,等.页岩气井可压裂性综合评价方法研究及应用[J].油气地质与采收率,2016,23(2):121-126.
• [14]陆程,刘雄,程敏华,等.页岩气体积压裂水平井产能影响因素研究[J].特种油气藏,2014,21(4):108-112.
• [15]杜殿发,付金刚,周志海,等.页岩气藏采收率计算方法探讨[J].特种油气藏,2015,22(5):74-77.
• [16]蒋廷学,卞晓冰,王海涛,等.页岩气水平井分段压裂排采规律研究[J].石油钻探技术,2013,41(5):21-25.
• [17]PENNY G S,PURSLEY J T,CLAWSON T D.Field study of completion fluids to enhance gas production in Barnett Shale[R].SPE 100434,2006.
• [18]戈尔布诺夫.异常油田开发[M].章树宝,译.北京:石油工业出版社,1987.
• [19]薛彦生.解析页岩气水平井钻完井和水力压裂技术[J].中国科技纵横,2013(23):154.
• [20]王莉,王红岩,魏伟,等.中国页岩气勘探开发适用技术探讨刘洪林[J].油气井测试,2009,18(4):68-72.
• [21]钱翔.通过革命性的创新完井技术实现增产[C].2012中国页岩气发展论坛,2012.
• [22]宗铁.国外页岩气勘探开发技术:中国石化页岩气勘探开发工程技术[C].2011:1-42.
• [23]栾永乐.国外页岩气主要钻井、开采技术调研[J].内蒙古石油化,2012(6):117-119.
• [24]刘洪林,王莉,王红岩,等.国外页岩气钻完井、储层改造技术现状及我国适应性分析[C].2009年全国油气井工程科学研究新进展与石油钻井工程技术高级研讨会,2009.
• [25]赵杰,罗森曼,张斌.页岩气水平井完井压裂技术综述[J].油气田开发,2012,30(1):48-52.
• [26]荣莽,罗君.页岩气藏水平井分段压裂管柱技术探讨[J].石油机械,2010,38(9):65-67.
• [27]王志刚.涪陵焦石坝地区页岩气水平井压裂改造实践与认识[J].石油与天然气地质,2014,35(3):425-430.
• [28]张小涛,吴建发,冯曦,等.页岩气藏水平井分段压裂渗流特征数值模拟[J].东北石油大学学报,2014,38(5):93-103.
• [29]袁旭军,曾俊.页岩气水平井压裂技术浅析[J].长江大学学报(自然科学版),2012,9(7):104-105.
• [30]刘红磊,熊炜,高应运,等.方深1井页岩气藏特大型压裂技术[J].石油钻探技术,2011,39(3):47-53.
• [31]李欣,段胜楷,侯大力,等.多级压裂页岩气水平井的不稳定生产数据分析[J].天然气工业,2012,32(12):44-48.
• [32]田冷,肖聪,刘明进,等.考虑页岩气扩散的多级压裂水平井产能模型[M].北京:石油工业出版社,2014.
• [33]路保平.中国石化页岩气工程技术进步及展望分析[J].石油钻探技术,2013,41(5):1-8.
• [34]贾长贵,路保平,蒋廷学,等.DY2HF深层页岩气水平井分段压裂技术[J].石油钻探技术,2014,42(2):85-90.
• [35]张烈辉、郭晶晶.页岩气藏无限导流多级压裂水平井试井模型[M].北京:石油工业出版社,2014.
• [36]杨松.页岩气水平井钻完井和水力压裂技术[J].油气地球物理,2013,11(2):9-11.
• [37]张会师.《非常规油气井压后排采推荐作法》标准编制说明[S].2012.
• [38]中国页岩气网新闻中心.胜利油田水平井多级分段压裂排采技术填补国内空白[EB/OL].[2014-06-11].http://www.csgcn.com.cn/news/show-42039.html.
• [39]刘新,张玉玮,钟显东,等.美国典型页岩油气藏水平井压裂技术[J].大庆石油地质与开发,2014,33(6):160-164.
• [40]纪天亮,卢双舫,唐明明,等.致密油藏水平井压裂后产能预测方法[J].大庆石油地质与开发,2016,35(2):165-169.
• [41]郑爱玲,刘德华.应力敏感对低渗致密气藏水平井压裂开采的影响[J].大庆石油地质与开发,2016,35(1):53-57.