尉雪梅,张艳玉,蒋文超,孙晓飞
WEI Xuemei,ZHANG Yanyu,JIANG Wenchao,SUN Xiaofei

• 1:中国石油大学(华东)石油工程学院
• 2:非常规油气开发教育部重点实验室(中国石油大学(华东))

摘要(Abstract)：

为定量表征不同黏土矿物对低矿化度水驱效果影响程度，分析低矿化度水驱的作用机理，采用黏土悬浮液对石英颗粒表面的高温黏附技术，制作了石英颗粒表面附着不同黏土矿物的填砂模型，并开展了岩心驱替实验和Zeta电位、接触角测试实验。结果表明：低矿化度水驱对纯石英砂填砂模型提高采收率效果不明显，黏土矿物的存在是低矿化度水驱提高采收率的必要条件；附着高岭石的石英砂模型的水驱采收率随注入水矿化度的降低呈提高趋势，附着蒙脱石的石英砂模型的水驱采收率在初期也随矿化度降低而逐渐升高，但存在一个最高采收率的临界矿化度，其后随注入水矿化度的进一步降低，最终采收率又呈现降低趋势；而蒙脱石黏土遇低矿化度水后，会使附着原油的蒙脱石颗粒膨胀运移而提高洗油效率，但随着离子质量浓度的降低，脱落的微粒增多，堵塞渗流通道，又会影响水驱效果；附着混合黏土岩心和附着蒙脱石岩心具有相似的水驱采收率变化规律，附着混合黏土的岩心模型的水驱效果要好于附着单一黏土矿物的岩心模型。
In order to quantitatively characterize the influence on low salinity waterflooding(LSWF)effects for different clay minerals and analyze the acting mechanism of LSWF,with the help of high temperature adhering technique of quartz particles surface by clay suspension,sand packed models are prepared for quartz particle surface adhered by different minerals,and core flooding experiments and experiments of Zeta potential and contact angle are carried out. The results show that LSWF has little effects for enhanced oil recovery of pure quartz sand packed model,existence of clay mineral is the necessary condition for enhancing LSWF recovery. Waterflooding recovery factor of quartz sand model attached with kaolinite increases singly with decrease of injected water salinity and recovery factor of quartz sand model attached with montmorillonite also gradually increases with salinity decrease in the initial stage,but there is a critical salinity with the highest recovery. With further decrease of injected water salinity,the ultimate recovery shows a trend of decrease. When montmorillonite meets with low salinity water,its particles will expand and migrate,thus enhance oil displacement efficiency. However,with decrease of ionic concentration,more micro-particles will fall off and block the flow path,which will influence waterflooding effects. Cores with attached mixed clay have similar change laws of waterflooding recovery with cores with attached montmorillonite,and core model with attached mixed clay has better waterflooding effect than that with attached single clay.

关键词(KeyWords)： 黏土矿物;低矿化度水驱;岩心驱替实验;采收率;Zeta电位
clay mineral;low salinity waterflooding(LSWF);core flooding experiment;recovery;Zeta potential

Abstract:

Keywords:

基金项目(Foundation): 国家科技重大专项“长水平井段SAGD多点均匀注汽方式与工艺研究”（2016ZX05031-002）;; 国家自然科学基金项目“稠油油藏人工泡沫油强化混合气体吞吐方法及其机理研究”（51604293）

作者(Author): 尉雪梅,张艳玉,蒋文超,孙晓飞
WEI Xuemei,ZHANG Yanyu,JIANG Wenchao,SUN Xiaofei

DOI: 10.19597/j.issn.1000-3754.202106027

参考文献(References)：

• [1]王平，姜瑞忠，王公昌，等.低矿化度水驱研究进展及展望[J].岩性油气藏，2012,24(2):106-110.WANG Ping,JIANG Ruizhong,WANG Gongchang,et al. Research advance and prospect of low salinity water flooding[J].Lithologic Reservoirs,2012,24(2):106-110.
• [2] SNOSY M F,ELA M A E,EL-BANBI A,et al.Comprehensive investigation of low-salinity waterflooding in sandstone reservoirs[J].Journal of Petroleum Exploration&Production Technology,2020,10:2019-2034.
• [3] BARTELS W B,MAHANI H,BERG S,et al.Literature review of low salinity waterflooding from a length and time scale perspective[J].Fuel,2019,236:338-353.
• [4]唐建信，徐斌，成田田，等.新型低矿化度活性水驱提高低渗砂岩油藏采收率技术[J].断块油气田，2020,27(6):789-793.TANG Jianxin,XU bin,CHENG Tiantian,et al.A new technology of active water flooding with low salinity to improve recovery of low permeability sandstone reservoir[J].Fault-Block Oil&Gas Field,2020,27(6):789-793.
• [5]李兆敏，赵艳玲，王海涛，等.注入水矿化度对盐间页岩油储层物性影响研究[J].特种油气藏，2020, 27(2):131-137.LI Zhaomin,ZHAO Yanling,WANG Haitao,et al.Effects of injection water salinity on physical properties of inter-salt shale oilreservoir[J].Special Oil&Gas Reservoirs, 2020, 27(2):131-137.
• [6] ELNAGGAR O M,TEMRAZ M G,AHMED M S.Effect of salinity degree of injected water on oil recovery carbonate reservoir[J]. Indian Journal of Geo-Marine Sciences, 2019, 48(1):32-37.
• [7] ZHANG L,ZHANG J X,WANG Y,et al.Experimental investigation of low salinity water flooding in a low-permeability oil reservoir[J].Energy&Fuels,2018,32(3):3108-3118.
• [8]李亚丽.渤海B油田低矿化度注水适用性研究[D].成都：西南石油大学，2018.LI Yali.Study on the applicability of low salinity water in jection in Bohai B Oilfield[D].Chengdu:Southwest Petroleum University,2018.
• [9] XIE Q,BRADY P V,POORYOUSEFY E,et al.The low salinity effect at high temperatures[J].Fuel,2017,200:419-426.
• [10] AMIRIAN T,HAGHIGHI M,MOSTAGHIMI P.Pore scale visualization of low salinity water flooding as an enhanced oil recovery method[J].Energy&Fuels,2017,31(12):13133-13143.
• [11] ALHURAISHAWY A K,BAI B J,WEI M Z,et al.Mineral dissolution and fine migration effect on oil recovery factor by low-salinity water flooding in low-permeability sandstone reservoir[J].Fuel,2018,220:898-907.
• [12] ALSARIHI A,ZEINIJAHROMI A,GENOLET L,et al.Effects of fines migration residual oil during low-salinity waterflooding[J].Energy&Fuels,2018,32(8):8296-8309.
• [13]崔传智，韦自健，吴忠维，等.基于DLVO理论的低矿化度水驱对岩石润湿性的影响[J].中国石油大学学报（自然科学版），2020,44(1):106-114.CUI Chuanzhi,WEI Zijian, WU Zhongwei,et al.Effect of lowsalinity waterflooding on rock wettability based on DLVO theory[J].Journal of China University of Petroleum(Edition of Natural Science), 2020, 44(1):106-114.
• [14] LOAHARDJO N,XIE X N,MORROW N R. Oil recovery by sequential waterflooding of mixed-wet sandstone and limestone[J]. Energy&Fuels,2010,24(9):5073-5080.
• [15]薛永安，王飞龙，汤国民，等.渤海海域页岩油气地质条件与勘探前景[J].石油与天然气地质，2020, 41(4):696-709.XUE Yong’an,WANG Feilong,TANG Guomin,et al.Geological condition and exploration prospect of shale oil and gas in the Bohai Sea[J].Oil&Gas Geology,2020,41(4):696-709.
• [16] REZAEIGOMARI S,ANDRADE A D. Study of the effect of illite and kaolinite on low salinity water injection[J]. International Journal of Engineering Research&Applications,2015,5(7):16-22.
• [17] GOMARI S R,JOSEPH N.Study of the effect of clay particles on low salinity water injection in sandstone reservoirs[J].Energies,2017,10(3):322-333.
• [18] REZAEIDOUST A,PUNTERVOLD T,STRAND S,et al.Smart water as wettability modifier in carbonate and sandstone:A discussion of similarities/differences in the chemical mechanisms[J]. Energy&Fuels,2009,23(9):4479-4485.
• [19] AHMETGAREEV V, ZEINIJAHROMI A, BADALYAN A,et al.Analysis of low salinity water flooding in Bastrykskoye Field[J]. Petroleum Science&Technology, 2015, 33(5):561-570.
• [20] NASRALLA R A,NASR-EL-DIN H A. Impact of cation type and concentration in injected brine on oil recovery in sandstone reservoirs[J].Journal of Petroleum Science&Engineering,2014,122:384-395.
• [21] CHEN Y Q,XIE Q,SAEEDI A. Role of ion exchange,surface complexation,and albite dissolution in low salinity water flooding in sandstone[J].Journal of Petroleum Science&Engineering,2019,176:126-131.
• [22] TANG G Q,MORROW N R.Influence of brine composition and fines migration on crude oil brine rock interactions and oil recovery[J]. Journal of Petroleum Science&Engineering, 1999, 24(2-4):99-111.
• [23] FOGDEN A,KUMAR M,MORROW N R,et al. Mobilization of fine particles during flooding of sandstones and possible relations to enhanced oil recovery[J].Energy&Fuels,2011,25(4):1605-1616.
• [24] AGBALAKA C C,DANDEKAR A Y, PATIL S L,et al. Coreflooding studies to evaluate the impact of salinity and wettability on oil recovery efficiency[J].Transport in Porous Media,2008,76(1):77-94.
• [25] ALAGIC E, SKAUGE A. Combined low salinity brine injection and surfactant flooding in mixed-wet sandstone cores[J]. Energy&Fuels,2010, 24(6):3551-3559.
• [26] LARER A,WEBB K J,BLACK C J J,et al. Low salinity oil recovery-An experimental investigation[J].Petrophysics,2008,49(1):28-35.
• [27] REZAEIDOUST A,PUNTERVOLD T,AUSTAD T.Chemical verification of the EOR mechanism by using low saline/smart water in sandstone[J].Energy&Fuels,2011,25(5):2151-2162.
• [28] CISSOKHO M,BOUSSOUR S,CORDIER P,et al.Low salinity oil recovery on clayey sandstone:Experimental study[J].Petrophysics,2010,51(5):305-313.
• [29]彭颖锋，李宜强，张威，等.龙西地区扶余油层致密砂岩矿物特征及其对开发效果的影响[J].大庆石油地质与开发，2021,40(1):162-174.PENG Yingfeng,LI Yiqiang,ZHANG Wei,et al. Mineral characteristics of tight sandstone in Fuyu reservoir of Longxi area and its influence on development effect[J]. Petroleum Geology&Oilfield Development in Daqing,2021,40(1):162-174.
• [30]武兴，王安成，巩联浩，等.致密砂岩油藏吞吐水驱开发微观孔隙动用特征[J].大庆石油地质与开发，2021,40(4):145-153.WU Xing,WANG Ancheng,GONG Lianhao,et al.Micro-pore producing characteristics of tight sandstone oil reservoir displaced by huff-puff waterflooding[J].Petroleum Geology&Oilfield Development in Daqing,2021,40(4):145-153.