吴淑云,黄丽,孙刚,许关利
Wu Shu-yun, et al. ( Exploration and Development Research Institute of Daqing Oilfield Company Ltd. , Daqing 163712, China)

• 1:大庆油田有限责任公司勘探开发研究院
• 2:大庆油田有限责任公司勘探开发研究院
• 3:大庆油田有限责任公司勘探开发研究院
• 4:大庆油田有限责任公司勘探开发研究院 黑龙江大庆163712

摘要(Abstract)：

针对目前油田广为使用的LVDVⅡ+型粘度计在所要求的测试条件下无法直接检测出粘度大于100mPa.s的聚合物溶液体系粘度值的问题,提出首先测量较低剪切速率范围的粘度数据并绘制粘度曲线,然后利用幂律方程对曲线进行拟合,再根据拟合方程计算出所需要的剪切速率为7.34s-1下的粘度值检测方法。将粘度大于100mPa.s的溶液体系的拟合粘度与流变仪实测粘度进行了对比,实验结果表明,该方法获得的数据准确可靠,可在油田相关领域推广应用。
At present, the widely used LVDVII + vis-eometer in oilfields can not directly measure the viscosity of polymer solution system with viscosity above 100 mPa ?s under the required measuring conditions ( UL rotator, and the shearing rate of 7. 34s-1). So, in this paper it is supposed to measure the viscosity data at lower shearing rate range and plot the viscosity curves firstly, and then with the application of power law equation to match the curve, and finally calculate the viscosity at the required shearing rate of 7. 31s"1 according to the matched equation. The comparing results between the matched viscosity of the solution system with the viscosity above lOOmPa ?s and the measured viscosity with viscometer suggest that the obtained data of this method are correct and reliable, and the method can be expanded and applied to fields.

关键词(KeyWords)： 聚合物溶液;粘度;粘度曲线;幂律方程
polymer solution; viscosity; viscosity curve; power law equation

Abstract:

Keywords:

基金项目(Foundation):

作者(Author): 吴淑云,黄丽,孙刚,许关利
Wu Shu-yun, et al. ( Exploration and Development Research Institute of Daqing Oilfield Company Ltd. , Daqing 163712, China)

参考文献(References)：

• [1]刘洪波,荆克尧.开展聚合物项目后评价工作的探讨[J].大庆石油地质与开发,2001,20(5):50-52.
• [2]Gebhard Schramm著,李晓晖译.实用流变测量学[M].北京:石油工业出版社,1998.
• [3]马德柱,何平笙,徐种德,等.高聚物的结构与性能[M].北京:科学出版社,1999,323-324.
• [4][英]HA巴勒斯,J H赫顿,K瓦尔特斯著,吴大诚古大治译校.流变学导引[M].北京:中国石化出版社,1992,25-27.